行業資訊
撒布車冬季維修保養不可不做的事項
來源：http://lzqdw.com/ 日期：2023-03-22
入冬前，我們要對自己的愛車及時保養，使車輛以佳狀態以備來年使用。今天，水泥撒布車出租人員就給大家的愛車進行“主動預防”，在冬季來臨之前，給大家介紹一下車輛入冬后的保養小知識。
Before winter, we need to maintain our beloved car in a timely manner to keep it in good condition for use in the coming year. Today, the rental staff of the cement spreader truck will conduct "proactive prevention" for everyone's beloved car. Before winter comes, let's introduce some maintenance tips for the car after winter.
1、車輛入冬前，請檢查管路的卡箍，由于熱脹冷縮，防止卡箍變松，引起漏油、漏水、漏氣及灰塵進入發動機；
1. Before the vehicle enters winter, please check the clamps of the pipeline. Due to heat expansion and cold contraction, prevent the clamps from becoming loose, causing oil, water, air, and dust to enter the engine;
2、及時檢查副發動機防凍液是否符合當?shù)氐沫h(huán)境溫度；如果有具備條件的，可用冰點儀測量下防凍液的冰點溫度，發現冰點有所下降不適合車輛使用時應及時更換。冰點檢測儀下的-40℃防凍液測量冰點檢測儀下的-40℃防凍液測量
2. Timely check whether the auxiliary engine antifreeze meets the local ambient temperature; If conditions are met, the freezing point temperature of the antifreeze can be measured with a freezing point meter. If the freezing point is found to have decreased and is not suitable for vehicle use, it should be replaced in a timely manner. - 40 ℃ antifreeze measurement under the freezing point detector - 40 ℃ antifreeze measurement under the freezing point detector
3、注意副發動機機油的更換，及時更換適應當?shù)貧鉁氐臋C油。防止由于機油粘度過大，影響發動機的冷啟動?？筛鶕褂谜f明書上的要求，添加適應當?shù)氐蜏囟鹊臋C油。
3. Pay attention to the replacement of auxiliary engine oil, and timely replace the oil that adapts to the local temperature. Prevent cold starting of the engine due to excessive oil viscosity. Oil suitable for local low temperature can be added according to the requirements in the instruction manual.
4、提前選擇能適應當?shù)貧夂虻娜加?，避免燃油結蠟，堵塞油路，影響發動機的正常工作。
4. Select fuel that can adapt to the local climate in advance to avoid fuel waxing, blocking the fuel path, and affecting the normal operation of the engine.
5、水泥撒布車應存放于地勢較高的位置，避免因雨雪天氣而導致車輛被水浸泡。
5. The cement spreader should be stored at a high location to avoid soaking the vehicle in water due to rain and snow.
6、車輛入冬存放前務必要將車內的物料全部排空，均整器、軟連接內殘留物料與板結塊必須全部清理干凈。
6. Before storing the vehicle in winter, it is necessary to empty all the materials in the vehicle, and the residual materials and plate lumps in the equalizer and soft connection must be completely cleaned.
7、利用上人孔裝過物料的，應對人孔處密封結構仔細檢查，確保車輛密封良好，避免雨水進入。
7. If materials have been loaded through the upper manhole, the sealing structure at the manhole should be carefully inspected to ensure that the vehicle is well sealed and prevent rainwater from entering.
8、對水泥撒布車除塵系統檢查，以確認除塵系統是否需要維護保養及更換配件。
8. Inspect the dust removal system of the cement spreader to confirm whether the dust removal system requires maintenance and replacement of accessories.
9、對車輛液壓系統檢查，以確認液壓系統是否需要維護保養。
9. Inspect the vehicle's hydraulic system to confirm whether it requires maintenance.
工程機械的維修保養工作務必要細心，只有綜合各方面的原因，才能迅速提升工作性能及工作效率，從根本上解決設備可能出現的故障或安全隱患，實現維修保養的戰略目的。更多相關內容就來我們網站http://lzqdw.com咨詢！
The maintenance and repair work of construction machinery must be careful. Only by integrating various reasons can we quickly improve working performance and efficiency, fundamentally solve potential equipment failures or safety hazards, and achieve the strategic purpose of maintenance and repair. For more relevant content, please visit our website http://lzqdw.com consulting service
公司地址：濟南市槐蔭區經一路273號群盛華城2號樓1-404
公司名稱：山東途暢路橋工程有限公司 
備案號：